Click
here to download the Mini Vaporizer Brochure
Installation Instructions
The mini vaporizer system is to be mounted on a flat and level wall surface in close proximity of the odor source, 4 Ft from ground level with the units control panel appearing at approx. eye level. It is not recommended that the unit be installed outside and the unit should be protected from freezing conditions at all times. The unit should be located in a clean dry area and situated such that the control panel is easy to see and use. Do not locate the unit in an area where it could be damaged by movement of a garbage compactor during an empting operation or where a garbage truck or other vehicle could damage the unit.
Attach the flanges located on the back of the unit to the wall surface with 10 each #10 screws and wall anchors making sure the unit is level after installation. If a wall surface is not available in a suitable position, an optional mounting pedestal (Part# MMFP0001) is available.
Hose Installation
The Mini Vaporizer System discharges a vapor of odor neutralizing droplets via a stainless steel tube located on the top of the unit. The unit can be installed to discharge the vapor directly into an odorous environment or room. Alternatively a 1 1/2" flexible hose can be attached to the discharge tube to convey the vaporized odor neutralizer directly to the odor source such as a garbage compactor, sewage tank or garbage chute. The hose must be less that 20Ft in length and installed to avoid kinking or sagging. Install the hose to avoid forming a pee trap / u-bend that will allow liquid to accumulate. If this is unavoidable, simply drill a 1/8" diameter hole in the bottom of the hose at the point where the liquid is expected to form.
START
UP
Position a full
5 gallon pail of odor neutralizer into the control units lower
cabinet, insert the siphon hose into the pail as it is being
positioned in the cabinet.
Plug the unit into a 115 vAC outlet, to start the vaporizer system
up, press the
SYSTEM ON / OFF button.
By default, the sprayer system will run for 15 seconds, and then
remain off for 30 minutes.
The
TIME OFF and
TIME ON can be easily
adjusted by pressed the
INCREASE or
DECREASE buttons to the
left and right sides of the display.
Set the cycle times according to your odor control situation. The
default cycle time makes a 5 gallon pail of Piian Odor Neutralizer
last 12 months and is sufficient for normal odor control
circumstances.
The sprayer system can be operated temporarily by pressing and
holding the
MANUAL ON button.
If the
SOLUTION LEVEL LED is Green
then the vaporizer system has odor neutralizer solution.
If the
SOLUTION LEVEL LED is Red, then
the vaporizer system has run out of odor neutralizer
solution.
MAINTENANCE
Odor Neutralizer Refill
When the system
has emptied the 5 Gallon pail of Odor Neutralizer an intermittent
beep alarm will sound. The
SOLUTION LEVEL LED will turn
from Green to Red. Press the
ALARM CLEAR button to
silence the alarm.
A siphon hose is located through the hole in top of the pail.
Carefully remove the hose from the pail.
Replace the empty pail with a full 5 gallon drum of Piian odor
Neutralizer.
Carefully reinsert the siphon hose back into the pail
opening.
To restart the sprayer system, press the
SYSTEM ON / OFF button.
General
Make sure the
unit and the control panel stays clean. Keep the cabinet door
closed and keep the control panel cover closed.
SPECIAL
NOTE ON ODOR NEUTRALIZER
The Mini Sprayer
unit is designed to pump Piian Odor Neutralizer; it will pump other
odor neutralizers. However, other odor neutralizers or masking
agents that contain isopropyl or de-natured alcohols or synthetic
fragrances (i.e. benzaldehide) are known to cause detrimental
reactions to the common sealing and pumping components found in
virtually all types of commercially available pumping systems. No
provision for this type of failure is allowed for in the warranty
of this system and the owner/user of this system who dispenses such
materials or any other toxic, reactive or corrosive material from
the Micro Mist system does so at their own risk.
Operation
Instructions
BASIC
INFORMATION
This system vaporizes odor neutralizer for control of odors.
Odor neutralizer fluid is drawn out of a 5 Gallon pail located
inside the lower cabinet.
The odor neutralizer fluid is vaporized via a tube/hose connected
to the top of the vaporizer.
The hose is to be positioned to discharge into the odorous
area/environment.
The vaporizer system operates by cycling ON and OFF
automatically.
SYSTEM
OPERATION
To start the vaporizer system up, press the SYSTEM ON/OFF
button.
By default, the vaporizer system will run for 15 seconds, and then
remain off for 30 minutes.
The TIME OFF and TIME ON can be easily adjusted by pressed the
INCREASE or DECREASE buttons to the left and right sides of the
display.
Set the cycle times according to your odor control situation. The
default cycle time makes a 5 gallon pail of Piian Odor Neutralizer
last 12 months and is sufficient for normal odor control
circumstances.
The vaporizer system can be operated temporarily by pressing and
holding the MANUAL ON button.
If the SOLUTION LEVEL LED is Green then the vaporizer system has
odor neutralizer solution.
If the SOLUTION LEVEL LED is Yellow then the vaporizer system is
low of neutralizer solution.
If the SOLUTION LEVEL LED is Red, then the vaporizer system has run
out of odor neutralizer solution.
REFILLING
THE SYSTEM
When the system has emptied the 5 Gallon pail of Odor Neutralizer
an intermittent beep alarm will sound. The SOLUTION LEVEL LED will
turn from Green to Red. Press the ALARM CLEAR button to silence the
alarm.
Open the lower cabinet door & remove the empty pail. A siphon
hose is located through the hole in top of the pail. Carefully
remove the hose from the pail as you remove the pail from the
cabinet.
Place a full 5 Gallon pail of Piian Odor Neutralizer Commercial
Concentrate (Part # PNCC0501) back in to the cabinet; carefully
reinsert the siphon hose back into the pail opening. Close the
cabinet door.
To restart the vaporizer system, press the SYSTEM ON / OFF
button.
WARNING
This vaporizer system will cease to operate at temperatures below
40 Deg F and the LOW TEMP SHUT OFF LED will illuminate. A glow plug
will prevent liquid freezing in the vaporizer system. The vaporizer
system will automatically restart once the temperature rises above
40 Deg F.
This vaporizer system is designed to dispense Piian Odor
Neutralizer Commercial Concentrate (Part# PNCC0501); other odor
neutralizing materials may not be compatible with this vaporizer
system. Use of incompatible materials will void all
warranties.
Do not add anything to the odor neutralizer material such as
antifreeze, fragrances or similar. These materials are incompatible
with the odor neutralizer material and this vaporizer system,
addition of such materials will void all warranties.
Piian Systems is not responsible for dispersion of any toxic,
flammable, corrosive or other potentially hazardous materials from
this system.